1990 Audi 100 fuel delivery problem
11-16-2006 | 01:10 PM
#1
Guest
Posts: n/a
1990 Audi 100 fuel delivery problem
Going crazy here. My Audi 100 will not start after sitting a day or so
in damp weather. Cold weather is okay - it seems to be the moisture
that's killing me. Weird thing is, the ignition spark is fine, but fuel
is not reaching the cylinders. If I put a heat lamp under the hood for
an hour or so, it starts fine. This makes me think it's an electrical
problem related to fuel delivery - but not the fuel pump. I wanted to
try changing out the Engine Control Unit, but don't know where it is
located. Any advice? Thanks!
in damp weather. Cold weather is okay - it seems to be the moisture
that's killing me. Weird thing is, the ignition spark is fine, but fuel
is not reaching the cylinders. If I put a heat lamp under the hood for
an hour or so, it starts fine. This makes me think it's an electrical
problem related to fuel delivery - but not the fuel pump. I wanted to
try changing out the Engine Control Unit, but don't know where it is
located. Any advice? Thanks!
11-18-2006 | 02:05 AM
#2
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
My first thought would be that you have a faulty contact in the fuel pump relay.
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
11-18-2006 | 02:05 AM
#3
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
My first thought would be that you have a faulty contact in the fuel pump relay.
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
11-18-2006 | 02:05 AM
#4
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
My first thought would be that you have a faulty contact in the fuel pump relay.
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
11-18-2006 | 02:05 AM
#5
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
My first thought would be that you have a faulty contact in the fuel pump relay.
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
You might also have a sticky air metering plate. It is located just above the
air filter in the intake manifold. Reach in above the air filter and gently push
the plate upwards if it is sticky it might not move when cold and that will keep
the fuel from flowing to the injectors.
Faulty fuel frequency valve. You may want to look that up elsewhere. I only
suspect it but have no personal experience.
Also search on the differential fuel pressure switch. Located on the front of
the fuel distributor.
Also be sure you are not loosing vacuum from the decel valve located in the
fender beside the air cleaner.
T44s can be fun to find a problem like this but a bit of searching should solve
the problem. Test parts before throwing money at the problem.
You may want to search the history on AudiWorld.com T44 forum:
http://forums.audiworld.com/v8/
TonyJ
Former four T44s (last one '91 100QM)
current '04 A4 1.8TQM
dabanfield@hotmail.com wrote:
> Going crazy here. My Audi 100 will not start after sitting a day or so
> in damp weather. Cold weather is okay - it seems to be the moisture
> that's killing me. Weird thing is, the ignition spark is fine, but fuel
> is not reaching the cylinders. If I put a heat lamp under the hood for
> an hour or so, it starts fine. This makes me think it's an electrical
> problem related to fuel delivery - but not the fuel pump. I wanted to
> try changing out the Engine Control Unit, but don't know where it is
> located. Any advice? Thanks!
>
11-18-2006 | 02:45 PM
#6
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
I have only worked on one Audi 100 for a crank sprocket problem but here are
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
11-18-2006 | 02:45 PM
#7
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
I have only worked on one Audi 100 for a crank sprocket problem but here are
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
11-18-2006 | 02:45 PM
#8
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
I have only worked on one Audi 100 for a crank sprocket problem but here are
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
11-18-2006 | 02:45 PM
#9
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
I have only worked on one Audi 100 for a crank sprocket problem but here are
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
my other experiences.....
I have been replacing some faulty ign. coils in 94-98 Jettas. The original
ign. coils fail due to moisture allowing the spark to short at the coil and
the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
I would want to either see the spark your coil is producing or examine the
spark plugs to see if they are wet or dry? A wide spark plug electrode gap
along with a weak spark might create problems in either cold or moist
conditions. AFAIK The spark will change under compression too!
Of course the spark plug wires are also affected by moisture!
Have you replaced anything related to the ign. system recently? Engine tune
or service?
Spark plugs, wires, distributor cap and rotor should get changed
periodically.
Also check in the Bentley for proper testing of the fuel delivery system.
I have seen bad or missing fuses cause the fuel not to flow.
Moisture might affect the wiring terminals at the Coolant Temperature Sensor
for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
connections
Does your Audi have blink codes?
later,
dave
(One out of many daves)
"Tony" <tonyjnospam@nospamvisi.com> wrote in message
news:12ltc5ho8t8iq6b@corp.supernews.com...
> My first thought would be that you have a faulty contact in the fuel pump
> relay.
>
> You might also have a sticky air metering plate. It is located just above
> the air filter in the intake manifold. Reach in above the air filter and
> gently push the plate upwards if it is sticky it might not move when cold
> and that will keep the fuel from flowing to the injectors.
>
> Faulty fuel frequency valve. You may want to look that up elsewhere. I
> only suspect it but have no personal experience.
>
> Also search on the differential fuel pressure switch. Located on the front
> of the fuel distributor.
>
> Also be sure you are not loosing vacuum from the decel valve located in
> the fender beside the air cleaner.
>
> T44s can be fun to find a problem like this but a bit of searching should
> solve the problem. Test parts before throwing money at the problem.
>
> You may want to search the history on AudiWorld.com T44 forum:
> http://forums.audiworld.com/v8/
>
> TonyJ
> Former four T44s (last one '91 100QM)
> current '04 A4 1.8TQM
>
> dabanfield@hotmail.com wrote:
>> Going crazy here. My Audi 100 will not start after sitting a day or so
>> in damp weather. Cold weather is okay - it seems to be the moisture
>> that's killing me. Weird thing is, the ignition spark is fine, but fuel
>> is not reaching the cylinders. If I put a heat lamp under the hood for
>> an hour or so, it starts fine. This makes me think it's an electrical
>> problem related to fuel delivery - but not the fuel pump. I wanted to
>> try changing out the Engine Control Unit, but don't know where it is
>> located. Any advice? Thanks!
>>
11-18-2006 | 03:11 PM
#10
Guest
Posts: n/a
Re: 1990 Audi 100 fuel delivery problem
The '90 100 doesn't have coil packs. Main ign coil and plug wires.
He might want to try to test the cold start injector but routing 12V directly to
it while cranking to start.
Tony
dave AKA vwdoc1 wrote:
> I have only worked on one Audi 100 for a crank sprocket problem but here are
> my other experiences.....
> I have been replacing some faulty ign. coils in 94-98 Jettas. The original
> ign. coils fail due to moisture allowing the spark to short at the coil and
> the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
> I would want to either see the spark your coil is producing or examine the
> spark plugs to see if they are wet or dry? A wide spark plug electrode gap
> along with a weak spark might create problems in either cold or moist
> conditions. AFAIK The spark will change under compression too!
> Of course the spark plug wires are also affected by moisture!
>
> Have you replaced anything related to the ign. system recently? Engine tune
> or service?
> Spark plugs, wires, distributor cap and rotor should get changed
> periodically.
>
> Also check in the Bentley for proper testing of the fuel delivery system.
> I have seen bad or missing fuses cause the fuel not to flow.
>
> Moisture might affect the wiring terminals at the Coolant Temperature Sensor
> for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
> connections
>
> Does your Audi have blink codes?
>
> later,
> dave
> (One out of many daves)
>
> "Tony" <tonyjnospam@nospamvisi.com> wrote in message
> news:12ltc5ho8t8iq6b@corp.supernews.com...
>
>>My first thought would be that you have a faulty contact in the fuel pump
>>relay.
>>
>>You might also have a sticky air metering plate. It is located just above
>>the air filter in the intake manifold. Reach in above the air filter and
>>gently push the plate upwards if it is sticky it might not move when cold
>>and that will keep the fuel from flowing to the injectors.
>>
>>Faulty fuel frequency valve. You may want to look that up elsewhere. I
>>only suspect it but have no personal experience.
>>
>>Also search on the differential fuel pressure switch. Located on the front
>>of the fuel distributor.
>>
>>Also be sure you are not loosing vacuum from the decel valve located in
>>the fender beside the air cleaner.
>>
>>T44s can be fun to find a problem like this but a bit of searching should
>>solve the problem. Test parts before throwing money at the problem.
>>
>>You may want to search the history on AudiWorld.com T44 forum:
>>http://forums.audiworld.com/v8/
>>
>>TonyJ
>>Former four T44s (last one '91 100QM)
>>current '04 A4 1.8TQM
>>
>>dabanfield@hotmail.com wrote:
>>
>>>Going crazy here. My Audi 100 will not start after sitting a day or so
>>>in damp weather. Cold weather is okay - it seems to be the moisture
>>>that's killing me. Weird thing is, the ignition spark is fine, but fuel
>>>is not reaching the cylinders. If I put a heat lamp under the hood for
>>>an hour or so, it starts fine. This makes me think it's an electrical
>>>problem related to fuel delivery - but not the fuel pump. I wanted to
>>>try changing out the Engine Control Unit, but don't know where it is
>>>located. Any advice? Thanks!
>>>
>
>
>
He might want to try to test the cold start injector but routing 12V directly to
it while cranking to start.
Tony
dave AKA vwdoc1 wrote:
> I have only worked on one Audi 100 for a crank sprocket problem but here are
> my other experiences.....
> I have been replacing some faulty ign. coils in 94-98 Jettas. The original
> ign. coils fail due to moisture allowing the spark to short at the coil and
> the aftermarket coils fail (quickly too) allowing a weak spark at the plug.
> I would want to either see the spark your coil is producing or examine the
> spark plugs to see if they are wet or dry? A wide spark plug electrode gap
> along with a weak spark might create problems in either cold or moist
> conditions. AFAIK The spark will change under compression too!
> Of course the spark plug wires are also affected by moisture!
>
> Have you replaced anything related to the ign. system recently? Engine tune
> or service?
> Spark plugs, wires, distributor cap and rotor should get changed
> periodically.
>
> Also check in the Bentley for proper testing of the fuel delivery system.
> I have seen bad or missing fuses cause the fuel not to flow.
>
> Moisture might affect the wiring terminals at the Coolant Temperature Sensor
> for the Fuel Injection, the Fuel Pressure Regulator or maybe some ground
> connections
>
> Does your Audi have blink codes?
>
> later,
> dave
> (One out of many daves)
>
> "Tony" <tonyjnospam@nospamvisi.com> wrote in message
> news:12ltc5ho8t8iq6b@corp.supernews.com...
>
>>My first thought would be that you have a faulty contact in the fuel pump
>>relay.
>>
>>You might also have a sticky air metering plate. It is located just above
>>the air filter in the intake manifold. Reach in above the air filter and
>>gently push the plate upwards if it is sticky it might not move when cold
>>and that will keep the fuel from flowing to the injectors.
>>
>>Faulty fuel frequency valve. You may want to look that up elsewhere. I
>>only suspect it but have no personal experience.
>>
>>Also search on the differential fuel pressure switch. Located on the front
>>of the fuel distributor.
>>
>>Also be sure you are not loosing vacuum from the decel valve located in
>>the fender beside the air cleaner.
>>
>>T44s can be fun to find a problem like this but a bit of searching should
>>solve the problem. Test parts before throwing money at the problem.
>>
>>You may want to search the history on AudiWorld.com T44 forum:
>>http://forums.audiworld.com/v8/
>>
>>TonyJ
>>Former four T44s (last one '91 100QM)
>>current '04 A4 1.8TQM
>>
>>dabanfield@hotmail.com wrote:
>>
>>>Going crazy here. My Audi 100 will not start after sitting a day or so
>>>in damp weather. Cold weather is okay - it seems to be the moisture
>>>that's killing me. Weird thing is, the ignition spark is fine, but fuel
>>>is not reaching the cylinders. If I put a heat lamp under the hood for
>>>an hour or so, it starts fine. This makes me think it's an electrical
>>>problem related to fuel delivery - but not the fuel pump. I wanted to
>>>try changing out the Engine Control Unit, but don't know where it is
>>>located. Any advice? Thanks!
>>>
>
>
>
